In order to make the generator set serve everyone better, users should pay attention to some use problems in the process of use. However, in the whole use process, some users still ignore some problems. For example, some users add too much oil when using. Today, I briefly introduced the problem of oil use. I hope it can be helpful to you!

一、油太多会导致什么问题

1、 What's the problem with too much oil

1.点火问题。您可能听说过发电机组的点火。造成这个问题的原因之一是柴油机油太多。由于机油过多导致柴油机油位升高，在曲轴负载下很容易造成燃气混合。当发电机组的工作温度升高时，它将着火并点燃，甚至可能导致曲轴箱出现一些紧急使用问题。

1. Ignition problem. You may have heard of the ignition of a generator set. One of the reasons for this problem is too much diesel oil. Because the oil level of diesel engine rises due to too much oil, it is easy to cause gas mixing under crankshaft load. When the working temperature of the generator set rises, it will catch fire and ignite, which may even lead to some emergency use problems of the crankcase.

2.提高油耗。发电机组的供油量与汽油量不同。发电机组柴油机充油过多时，发电机组发动机曲轴左右端容易漏出多余的柴油，造成柴油机的消耗和环境污染，这将增加柴油机维修的难度系数。

2. Improve fuel consumption. The oil supply of the generator set is different from that of gasoline. When the diesel engine of the generator set is overfilled, the left and right ends of the engine crankshaft of the generator set are easy to leak excess diesel, resulting in diesel engine consumption and environmental pollution, which will increase the difficulty coefficient of diesel engine maintenance.

二、正确的供油方法

2、 Correct oil supply method

1.打开发电机的油盖。里面有一个滤网。将滤网放置到位。先倒入柴油，然后给柴油机加油（注意必须处于满油状态，否则会有气体，以后无法正常启动）。

1. Open the oil cover of the generator set. There is a filter screen inside. Put the screen in place. First pour in diesel oil, and then refuel the diesel engine (note that it must be full of oil, otherwise there will be gas, and it will not start normally in the future).

2.将设备放置到位，打开柴油盖。油箱位于控制面板下方，有一个可拧在发动机缸体上的外盖。打开油盖后，滴油（敲黑板，滴油时放在这里，不能倾斜，斜加会造成气缸密封，设备不会发出声音）。当油满了，它被加到瓶塞上，瓶塞会流出来，也不会流出来，只要想想身体和人的眼睛就能看到油。

2. Place the equipment in place and open the diesel cover. The tank is located under the control panel and has an outer cover that can be screwed to the engine block. After opening the oil cover, drop the oil (knock on the blackboard and put it here when dropping the oil. It cannot be tilted. The oblique addition will cause the cylinder seal and the equipment will not make a sound). When the oil is full, it is added to the cork. The cork will flow out and will not flow out. Just think about the body and human eyes to see the oil.

三、关于石油供应的常见问题

3、 Frequently asked questions about oil supply

1.柴油机质量管理。加油时不要拆下汽油和柴油滤网，以免浮尘、污渍或其他外部污垢渗入柴油机。如果柴油机内充满不干净的东西，会损坏柴油机过滤机和设备，增加柴油机喷油嘴和油泵系统的损坏，对发电机的使用寿命有直接或间接的危害。

1. Diesel engine quality management. Do not remove the gasoline and diesel filter screen during refueling to avoid floating dust, stains or other external dirt penetrating into the diesel engine. If the diesel engine is filled with unclean things, it will damage the diesel filter and equipment, increase the damage of diesel fuel injection nozzle and oil pump system, and do direct or indirect harm to the service life of Yuchai generator set.

2.以适当的方式加油。用户在供油时应随时观察和检查油表，不得使汽油、柴油溢出或泄漏到柴油机和消声器上。如果发生意外溢出或泄漏，可在启动发电机前清洁柴油机。

2. Add oil in an appropriate way. The user shall observe and check the oil gauge at any time when supplying oil, and shall not overflow or leak gasoline and diesel to the diesel engine and muffler. In case of accidental spillage or leakage, clean the diesel engine before starting the generator set.

3.供油时间控制。只有在关闭汽油和柴油阀门并冷却发电机组后，才能向发电机组供油。厂家建议发电机组在整个运行过程中无需供油，因为在运行过程中供油时，机油很容易飞溅出来，存在风险。从长远来看，它还会危及发电机组的使用寿命。

3. Oil supply time control. Only after closing the gasoline and diesel valves and cooling the generator set can oil be supplied to the generator set. The manufacturer suggests that the generator set does not need oil supply during the whole operation, because the oil is easy to splash out during the operation, which is risky. In the long run, it will also endanger the service life of the generator set.