The leakage of generator set may be caused by the leakage of water pump, radiator and water pipe. Today, for the leakage of generator set, we share some treatment methods commonly used by technical service engineers. I hope I can help you.

1、解决淡水泵漏水问题

1. Solve the problem of water leakage of fresh water pump

（1）如果新鲜水泵监控孔也泄漏，请从阀体上取下新鲜水泵并拆卸，然后更换水封。

(1) If the fresh water pump monitoring hole also leaks, remove the fresh water pump from the valve body and disassemble it, and then replace the water seal.

（2）当安装在新鲜水泵上的排水阀由于弹簧损坏而泄漏时，可以更换弹簧或新的排水阀。维护人员应在排水阀的弹簧上涂润滑脂，以防止弹簧生锈。

(2) When the drain valve installed on the fresh water pump leaks due to spring damage, the spring or a new drain valve can be replaced. The maintenance personnel shall apply grease on the spring of the drain valve to prevent the spring from rusting.

2、散热器漏水的解决方案

2. Solution of radiator leakage

（1）散热器上下水室的维修方法：在检测到散热器的泄漏部分后，清洁泄漏的部分，然后用金属刷或刮刀完全清理干净金属漆和铁锈，然后用焊锡**。如果上下水室的固定螺钉中有大面积的漏水现象，可以将上下水室拆除，然后重新制作两个尺寸合适的水室。在组装上下水室之前，在垫片的***部和底部涂上粘合剂或密封剂，然后用螺钉将其固定。

(1) Maintenance method of radiator upper and lower water chamber: after detecting the leaking part of the radiator, clean the leaking part, and then completely clean the metal paint and rust with a metal brush or scraper, and then use solder * *. If there is a large area of water leakage in the fixing screws of the upper and lower water chambers, the upper and lower water chambers can be removed, and then two water chambers with appropriate size can be made again. Before assembling the upper and lower water chambers, apply adhesive or sealant to the * * * part and bottom of the gasket, and then fix it with screws.

（2）散热器水管的维修方法：如果在检测过程中发现散热器外水管的损坏面较小，可以通过焊接进行维修。如果损坏的部分很大，请使用尖嘴钳钳住损坏的管子的管端，以免其泄漏。但是，堵塞的管道数量不能过多，否则会影响散热器的散热效果。如果散热器的内部水管损坏，请拆下上下水室，并更换或焊接散热器的内部水管。

(2) Maintenance method of radiator water pipe: if the damaged surface of radiator outer water pipe is found to be small during the inspection, it can be repaired by welding. If the damaged part is large, use pointed nose pliers to clamp the pipe end of the damaged pipe to avoid leakage. However, the number of blocked pipes should not be too large, otherwise it will affect the heat dissipation effect of the radiator. If the inner water pipe of the radiator is damaged, remove the upper and lower water chambers and replace or weld the inner water pipe of the radiator.

3、水管泄漏解决方案当水管因老化而泄漏时，应立即换上新的水管。如果水管很难买到，可以用防水胶带包裹。如果是因为夹子生锈而发生漏水，则可以将夹子更换或用电线包裹。

3. Solution of water pipe leakage when the water pipe leaks due to aging, it shall be replaced with a new water pipe immediately. If water pipes are hard to buy, they can be wrapped with waterproof tape. If the water leakage is caused by the rust of the clip, the clip can be replaced or wrapped with wire.

以上就是为大家介绍的有关沼气发电机组https://www.huannengpower.cn的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务

The above is about the biogas generator set introduced to you https://www.huannengpower.cn I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service