济南济柴环能燃气发电设备有限公司全国服务热线:

0531-62325028
当前位置:首页>>新闻中心>>行业新闻>>柴油发电机不维护对机器有什么影响
分类导航
产品展示
联系我们
济南济柴环能燃气发电设备有限公司

联系电话:高经理18653152096

服务热线:0531-62325028

联系地址:济南市高新区舜华路2000号舜泰广场9号楼南楼201

柴油发电机不维护对机器有什么影响

来源:https://www.huannengpower.cn/ 文章作者:济柴环能 发布时间:2022-09-20
静音柴油发电机是需要做维护和保养的,静音柴油发电机的正常工作运行,静音柴油发电机出现的故障少,使用寿命长,这都和静音柴油发电机的正确维护和保养有这很大的关系。
The mute diesel generator needs to be maintained. The normal operation of the mute diesel generator, the few failures of the mute diesel generator and the long service life have a lot to do with the correct maintenance of the mute diesel generator.
1、冷却系统
1. Cooling system
如果说冷却系统有故障的话,会致使两个结果,1)冷却作用欠好而使机组内水温过高而停机;2)水箱漏水而使水箱内水位降低,机组也会无法正常作业。
If the cooling system fails, it will lead to two results: 1) the cooling effect is not good enough to make the water temperature in the unit too high and shut down; 2) The water level in the water tank will be lowered due to water leakage of the water tank, and the unit will also be unable to operate normally.
2、燃油/配气系统
2. Fuel/gas distribution system
积炭沉积量的增加致使喷油嘴喷油量将受到一定影响,致使喷油嘴焚烧不充分,发动机各缸喷油量也就不均匀,作业状况也就不稳定。
The increase of carbon deposition will affect the fuel injection quantity of the fuel injection nozzle to some extent, resulting in insufficient burning of the fuel injection nozzle, uneven fuel injection quantity of each cylinder of the engine, and unstable operation conditions.
3、电瓶
3. Battery
如果说电瓶长期不维护的话,电解液水分蒸发后就会得不到及时弥补,没有装备起动电瓶充电器,电瓶长期自然放电后电量降低。
If the battery is not maintained for a long time, the water in the electrolyte will not be compensated in time after evaporation. The battery charger is not equipped to start the battery, and the battery power will be reduced after long-term natural discharge.
4、机油
4. Oil
机油是有一定的坚持期,也就是说长期不使用的话,机油的物理化学功能会发生变化,形成机组作业时清洁度会恶化,会引发机组零件损坏。
The engine oil has a certain persistence period, that is to say, if it is not used for a long time, the physical and chemical functions of the engine oil will change, resulting in the deterioration of the cleanliness during the operation of the unit, which will cause damage to the unit parts.
5、油箱
5. Oil tank
水进入柴油发电机组空气中的水气在温度的改变下会发生冷凝现象,结成水珠挂附在油箱内壁,当水珠流入柴油后,就会使柴油含水量超标,当这样的柴油进入发动机高压油泵后,就会锈蚀精密偶合件,假设严重的话就会损坏机组。
The water vapor in the air of the diesel generator set will condense under the change of temperature, forming water droplets hanging on the inner wall of the oil tank. When the water droplets flow into the diesel oil, the water content of the diesel oil will exceed the standard. When such diesel oil enters the engine high-pressure oil pump, the precision coupling parts will be corroded, and if it is serious, the unit will be damaged.
6、三滤
6. Triple filtration
在柴油发电机组工作过程中,油污或杂质会沉积在滤网壁上,而过个会使滤器过滤功能下降,沉积过多,油路将无法疏通,当设备工作时将会因油无法供应而不能正常使用。
During the operation of the diesel generator set, oil dirt or impurities will deposit on the filter screen wall, which will reduce the filter function of the filter. If the deposit is too much, the oil circuit will not be unblocked, and the equipment will not be used normally due to the lack of oil supply.
7、润滑系统、密封件
7. Lubrication system, seals
由于润滑油或油酯的化学特性及机械磨损后发生的铁屑,这些不止降低了它的润滑效果,还会损坏其它零部件,一同由于润滑油对橡胶密封圈有一定的腐蚀效果,其它油封本身也随时而老化使其密封效果下降。
Due to the chemical properties of lubricating oil or oil ester and the iron filings after mechanical wear, these not only reduce its lubricating effect, but also damage other parts. Because the lubricating oil has a certain corrosion effect on the rubber seal ring, other oil seals are also aging at any time to reduce their sealing effect.
8、线路连接
8. Line connection
静音柴油发电机假设使用时间过长的话,线路接头就有可能松动,需要定期的检查。
If the silent diesel generator is used for too long, the line connector may be loose, and regular inspection is required.
以上就是为大家介绍的有关焦化气发电机组的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务https://www.huannengpower.cn
The above is a detailed introduction to the coking gas generator set, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide you with professional services https://www.huannengpower.cn

声明:文章来源于https://www.huannengpower.cn/

相关产品 / Related products

联系我们
    济南济柴环能燃气发电设备有限公司
  • 国内业务:高经理18653152096
    王经理13012995645
  • 国外业务:李经理18668968402
    张经理18678860619
  • 座 机:0531-62325028 / 69951266
  • 传 真:0531-69958299
  • 邮 箱:hengnenghr@163.com
  • 地 址:济南市高新区舜华路2000号舜泰广场9号楼南楼201
济南济柴环能燃气发电设备有限公司     网站备案号:鲁ICP备18052890号-3 技术支持:网站建设·推广运营 流量统计: 网站地图 XML TXT

截屏,微信识别二维码

微信号:王经理13012995645

点击微信号复制,添加好友

 打开微信