济南济柴环能燃气发电设备有限公司全国服务热线:

0531-62325028
当前位置:首页>>新闻中心>>行业新闻>>发电机组夏季温度过高怎么办?
分类导航
产品展示
联系我们
济南济柴环能燃气发电设备有限公司

联系电话:高经理18653152096

服务热线:0531-62325028

联系地址:济南市高新区舜华路2000号舜泰广场9号楼南楼201

发电机组夏季温度过高怎么办?

来源:https://www.huannengpower.cn/ 文章作者:济柴环能 发布时间:2022-07-26
很多客户在使用柴油发电机组时会遇到各种故障问题,比如发电机组温度高,有时甚至烫手,不知道是怎么回事。正常情况下柴油发电机组在运行中都会产生很多热能,并且有很高的温度这些都是正常的现象;如果机组温度过高就会导致润滑油粘度下降,影响发电机组的性能,以及出现各种故障。
Many customers will encounter various faults when using diesel generator sets, such as high temperature of generator sets, and sometimes even hot hands. They don't know what's going on. Under normal circumstances, diesel generator sets will produce a lot of heat energy during operation, and there are very high temperatures, which are normal phenomena; If the temperature of the unit is too high, the viscosity of the lubricating oil will decrease, affecting the performance of the generator set and various faults will occur.
柴油发电机组温度过高有办法吗?
Is there any way to prevent the diesel generator set from overheating?
通风:机房要做好通风处理,并且避免机组长期负荷运转,以免冷却液温度过高。
Ventilation: the machine room should be well ventilated, and the long-term load operation of the unit should be avoided to avoid excessive coolant temperature.
保持散热器清洁:散热器外部沾有大量粉尘、油渍时都会影响散热效果,造成冷却液温度过高。平时要对机组散热器及时清洗或者修整。
Keep the radiator clean: a large amount of dust and oil stains on the outside of the radiator will affect the heat dissipation effect and cause the coolant temperature to be too high. The radiator of the unit shall be cleaned or repaired in time at ordinary times.
水箱清洁:冷却水箱如果积有大量的水垢、泥砂等也会影响冷却液的传热。因此平时要添加优质的冷却液,不要添加劣质冷却液或水,劣质冷却液会造成水垢增多,从而使得冷却效果变差。
Water tank cleaning: if there is a large amount of scale, mud and sand in the cooling water tank, it will also affect the heat transfer of the coolant. Therefore, high-quality coolant should be added at ordinary times, and inferior coolant or water should not be added. Inferior coolant will cause scale to increase, thus making the cooling effect worse.
冷却液保持充足:冷却液要位于水箱的高和低标志之间,低于低标志时要及时添加。冷却液也不能注入的太满应留有膨胀余地。
Keep sufficient coolant: the coolant should be located between the high and low marks of the water tank, and it should be added in time when it is lower than the low mark. The coolant cannot be filled too full, and there should be room for expansion.
风扇胶带力度适中:风扇胶带过松会使水泵转速过低影响冷却液循环,风扇胶带过紧又会使水泵轴承磨损严重。因此要保持风扇胶带张紧力度适中,平时应定期检查调整。
The strength of fan tape is moderate: too loose fan tape will make the water pump rotate too slowly and affect the coolant circulation. Too tight fan tape will make the water pump bearing wear seriously. Therefore, the tension of fan tape should be kept moderate, and it should be checked and adjusted regularly at ordinary times.
超负荷下长期运行:机组长期进行超负荷工作就会现出耗油量增加、内部散热升高、冷却水开锅等现象。针对此种情况佳处理方法是避免长时间超负荷工作。
Long term operation under overload: if the unit is overloaded for a long time, there will be increased oil consumption, increased internal heat dissipation, boiling of cooling water and other phenomena. The best way to deal with this situation is to avoid long-term overload.
柴油发电机组在运转中出现温度过高的情况,严重的会造成拉缸等事故,如温度过高的话要及时检查维修,做好日
If the temperature of the diesel generator set is too high during operation, it will seriously cause cylinder pulling and other accidents. If the temperature is too high, it should be checked and repaired in time and daily work should be done well
以上就是为大家介绍的有关沼气发电机组的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务https://www.huannengpower.cn
The above is a detailed introduction about biogas generator set for you. I hope it can help you. If you have any questions, please contact us. We will provide services for you with a professional attitude https://www.huannengpower.cn

声明:文章来源于https://www.huannengpower.cn/

相关产品 / Related products

联系我们
    济南济柴环能燃气发电设备有限公司
  • 国内业务:高经理18653152096
    王经理13012995645
  • 国外业务:李经理18668968402
    张经理18678860619
  • 座 机:0531-62325028 / 69951266
  • 传 真:0531-69958299
  • 邮 箱:hengnenghr@163.com
  • 地 址:济南市高新区舜华路2000号舜泰广场9号楼南楼201
济南济柴环能燃气发电设备有限公司     网站备案号:鲁ICP备18052890号-3 技术支持:网站建设·推广运营 流量统计: 网站地图 XML TXT

截屏,微信识别二维码

微信号:王经理13012995645

点击微信号复制,添加好友

 打开微信